Preliminary evaluation of anhydrous ethanol as a solvent in the oilseed extraction of Jatropha curcas L.
DOI:
https://doi.org/10.3989/gya.087209Keywords:
Ethanol, Experimental factorial design, n- Hexane, Temperature, Time, Vegetable oilseedAbstract
A preliminary evaluation was performed on anhydrous ethanol as a solvent for the extraction of oil from whole Jatropha curcas L. seeds (32.24 % lipids, 16.05 % proteins), supplied from Mato Grosso, Brazil. The methodology of factorial 2k designs was followed, which included a comparison between pressing and n-hexane extraction methods. The regression model corresponding to the comparison between ethanol and n-hexane, varying extraction time, did not have lack of fit and presented an R2 of 99%. The experimental design for the pressing method, varying press rotation speed and temperature, yielded a poorly fitted linear model. The oil composition extracted with ethanol was similar to those obtained by n-hexane and by pressing. The highest yield (36.7%) was obtained using ethanol for 4 hours. The excess of extracted material was attributed to additional solubilization of impurities that could be diminished by limiting the extraction time to 1 hour. The oil extracted with ethanol and by pressing have the same color. It is presumed that the purification steps for both oils should be similar. Further studies using mixtures of ethanol with small proportions of n-hexane are suggested.
Downloads
References
Achten WMJ, Verchot L, Franken, YJ, Mathijs, E, Singh VP, Aerts R y Muys B. 2008. Jatropha bio-diesel production and use. Biomass & Bioenergy. 32, 1063-1084. doi:10.1016/j.biombioe.2008.03.003
Adriaans T. 2006. Suitability of solvent extraction for Jatropha curcas. Eindhoven: FACT Foundation. AOCS. 2008. Official methods and recommended practices of the American Oil Chemists Society. 4ta ed.
Firestone D. AOCS Press Champaign, Illinois, EEUU. Barros Neto B, Scarminio IS, Bruns RE. 1995. Planejamento e Otimização de Experimentos. Editora da UNICAMP. Campinas.
Bredeson DK. 1983. Mechanical Oil Extraction, Journal American Oil Chemical Society, 60.
Diemair W. 1963. Laboratoriumbuch Fur Lebens Mittelchemiker, 8aufl. Drisden: Verlag Von Theodor Steinkopft.
Drummond ARF, Gazineu MHP, Almeida L, Souto Maior A. Metanol e Etanol como Solventes na Extração de Aceite de Mamona. http://www.biodiesel.gov.br/docs/congressso2006/agricultura/Metanol.pdf
Garnayak DK, Pradhan RC, Naik SN y Bhatnagar N. 2008. Moisture-dependent physical properties of jatropha seed (Jatropha curcas L.). Industrial crops and Products, 27, 123-129. doi:10.1016/j.indcrop.2007.09.001
AOAC. 2006. Official methods of analysis of the Association of Official Analytical Chemists. 18 ed. Horwitz W. Gaithersburg, Maryland. EEUU.
Kumar A y Sharma S. 2008. An evaluation of multipurpose oil seed crop for industrial uses (Jatropha curcas L.): A review. Industrial Crops and Products, 2, 1–10. doi:10.1016/j.indcrop.2008.01.001
Lago RCA, Szpiz RR, Jablonka FH, Pereira DA y Hartman L. 1985. Extraction and transesterification of vegetable oils with ethanol. Oleagineux, 40, 147-151.
Marcus Y. 1999. The Properties of Solvents. John Wiley & Sons Ltd, New York.
Martínez -Herrera J, Siddhuraju P, Francis G, Dávila-Ortíz G y Becker K. 2006. Chemical composition, toxic/ antimetabolic constituents, and effects of different treatments on their levels, in four provenances of Jatropha curcas L. from Mexico. Food Chemistry, 96, 80–89. doi:10.1016/j.foodchem.2005.01.059
Montgomery DC. 2005. Design and Analysis of Experiments, 5th Edition Design.
Svarovsky L. 1990. Solid- Liquid Separation. 3ra. Ed, Butterworth & Co. Ltd.
Thomas GC. 2003. Análise Teórico Experimental da Extração de Óleo de Soja em Instalação Industrial do tipo Rotocell, Tese de Doutorado, Escola de Engenharia da Universidade Federal do Rio Grande do Sul, Brasil.
Ullmann’s Encyclopedia of Chemical Engineering, 1995. Willems P, Kuipers NJM y De Haan AB. 2008. Hydraulic pressing of oilseeds: Experimental determination and modeling of yield and pressing rates. Journal of Food Engineering, 89, 8-16.
Zavala Pope JM. 1972. Obtenção Industrial de Óleo do Farelo de Arroz. Tese de Mestrado, UNICAMP, São Paulo, 16-23.
Zenebon O y Pascuet NS. 2005. Métodos físico-químicos para análise de Alimentos. 4ed. Brasília: Ministério da Saúde/ANVISA, São Paulo: Instituto Adolfo Lutz.
Downloads
Published
How to Cite
Issue
Section
License
Copyright (c) 2010 Consejo Superior de Investigaciones Científicas (CSIC)
This work is licensed under a Creative Commons Attribution 4.0 International License.
© CSIC. Manuscripts published in both the printed and online versions of this Journal are the property of Consejo Superior de Investigaciones Científicas, and quoting this source is a requirement for any partial or full reproduction.All contents of this electronic edition, except where otherwise noted, are distributed under a “Creative Commons Attribution 4.0 International” (CC BY 4.0) License. You may read here the basic information and the legal text of the license. The indication of the CC BY 4.0 License must be expressly stated in this way when necessary.
Self-archiving in repositories, personal webpages or similar, of any version other than the published by the Editor, is not allowed.
