Optimization of oligoglycerol fatty acid esters preparation catalyzed by Lipozyme 435

Authors

  • F. L. Wan Guangdong Saskatchewan Oilseed Joint Laboratory, Guangdong Engineering Technology Research Center for Oils and Fats Biorefi nery, Department of Food Science and Engineering, Jinan University
  • Y. L. Teng Guangdong Saskatchewan Oilseed Joint Laboratory, Guangdong Engineering Technology Research Center for Oils and Fats Biorefi nery, Department of Food Science and Engineering, Jinan University
  • Y. Wang Guangdong Saskatchewan Oilseed Joint Laboratory, Guangdong Engineering Technology Research Center for Oils and Fats Biorefi nery, Department of Food Science and Engineering, Jinan University
  • A. J. Li Guangdong Saskatchewan Oilseed Joint Laboratory, Guangdong Engineering Technology Research Center for Oils and Fats Biorefi nery, Department of Food Science and Engineering, Jinan University
  • N. Zhang Guangdong Saskatchewan Oilseed Joint Laboratory, Guangdong Engineering Technology Research Center for Oils and Fats Biorefi nery, Department of Food Science and Engineering, Jinan University

DOI:

https://doi.org/10.3989/gya.1180142

Keywords:

Biocat alysis, Bubble column reactor, Esterification, Immobilized enzyme, Lipase, Oligoglycerol fatty acid esters

Abstract


Oli goglycerol fatty acid esters (OGEs) are an important kind of polyglycerol fatty acid esters (PGEs) which have been widely used as emulsifiers in food, medicine and cosmetic industries. The aim of this study was to investigate the preparation of OGEs by the esterification of olig oglycerol with linoleic acid in a solvent- free system using Lipozyme 435 as the catalyst. The effects of substrate molar ratio, reaction time, reaction temperature, enzyme dosage, and water addition on the efficiency of esterification (EE) were studied. Single factor experiments and response surface methodology (RSM) were employed to optimize the reaction parameters. The optimum conditions were obtained as follows: reaction time 4.52 h, reaction temperature 90 °C, enzyme dosage 2 wt% (based on the total substrate mass), the molar ratio of oligoglycerol to linoleic acid 1.59:1 and no water addition. Under these conditions, the experimental EE (95.82±0.22%) fitted well with that predicted by RSM (96.15%). Similar results were obtained when the process was scaled up to a production of 500 g in a pilot bubble column reactor (BCR). The enzyme maintained 98.2% of the relative activity after 10 batches of reaction in the BCR. Electro spray ionization mass spectrum was employed to rapidly analyze the esterification products, and most species of OGEs have been identified.

Downloads

Download data is not yet available.

References

Andersen T, Holm A, Skuland IL, Trones R, Greibrokk T. 2003. Characterization of complex mixtures of polyglycerol fatty acid esters using temperature and solvent gradients in packed capillary LC. J. Sep. Sci. 26, 1133–1140. http://dx.doi.org/10.1002/jssc.200301538

Blasi F, Cossignani L, Simonetti MS, Damiani P. 2007. Biocatalysed synthesis of sn-1,3-diacylglycerol oil from extra virgin olive oil. Enzyme Microb. Tech. 41, 727–732. http://dx.doi.org/10.1016/j.enzmictec.2007.06.005

Byun HG, Eom TK, Jung WK, Kim SK. 2007. Lipase catalyzed production of monoacylglycerols by the esterification of fish oil fatty acids with glycerol. Biotechnol. Bioproc. E. 12, 491–496. http://dx.doi.org/10.1007/BF02931345

Brady C, Metcalfe L, Slaboszewski D, Frank D. 1988. Lipase immobilized on a hydrophobic microporous supports for the hydrolysis of fats. J. Am. Oil Chem. Soc. 65, 917–921. http://dx.doi.org/10.1007/BF02544510

Cassel S, Chaimbault P, Debaig C, Benvegnu T, Claude S, Plusquellec D, Rollin P, Lafosse M. 2001. Liquid chromatography of polyglycerol fatty esters and fatty ethers on porous graphitic carbon and octadecyl silica by using evaporative light scattering detection and mass spectrometry. J. Chromatog. A 919, 95–106. http://dx.doi.org/10.1016/S0021-9673(01)00801-9

Curschellas C, Kohlbrecher J, Geue T, Fischer P, Schmitt B, Rouvet M, Windhab EJ, Limbach HJ. 2013. Foams stabilized by multi lamellar polyglycerol ester self-assemblies. Langmuir 29, 38–49. http://dx.doi.org/10.1021/la3029116 PMid:23214931

Charlemagne D, Legoy MD. 1995. Enzymatic synthesis of polyglycerol-fatty acid esters in a solvent-free system. J. Am. Oil Chem. Soc. 72, 61–65. http://dx.doi.org/10.1007/BF02635780

Chowdary GV, Ramesh MN, Prapulla SG. 2000. Enzymic synthesis of isoamylisovalerate using immobilized lipase from Rhizomucormiehei: a multivariate analysis. Process Biochem. 36, 331–339. http://dx.doi.org/10.1016/S0032-9592(00)00218-1

Duan ZQ, Du W, Liu ZH. 2013. Improved synthesis of 1,3-diolein by Novozym 435 mediated esteri•cation of monoolein with oleic acid. J. Mol. Catal. B: Enzym. 89, 1–5. http://dx.doi.org/10.1016/j.molcatb.2012.12.003

Ding ZY, Hao AY, Wang ZN. 2007. Water-in-gasoline microemulsions stabilized by polyglycerol esters. Fuel 86, 597–602. http://dx.doi.org/10.1016/j.fuel.2006.07.028

Eom TK, Kong CS, Byun HG, Jung WK, Kim SK. 2010. Lipase catalytic synthesis of diacylglycerol from tuna oil and its anti-obesity effect in C57BL/6J mice. Process Biochem. 45, 738–743. http://dx.doi.org/10.1016/j.procbio.2010.01.012

Freitas L, Perez VH, Santos JC, Castro de HF. 2007. Enzymatic synthesis of glyceride esters in solvent-free system: influence of the molar ratio, lipase source and functional activating agent of the support. J. Brazil. Chem. Soc. 18, 1360–1366. http://dx.doi.org/10.1590/s0103-50532007000700011

Grifin WC. 1954. Calculation of HLB values of non-ionic surfactants. J. Soc. Cosmet. Chem. 5, 249–256.

Khemchyan LL, Khokhlova EA, Seitkalieva MM, Ananikov VP. 2013. Efficient sustainable tool for monitoring chemical reactions and structure determination in ionic liquids by ESI-MS. Chemistry Open 2, 208–214. http://dx.doi.org/10.1002/open.201300022 PMid:24551568 PMCid:PMC3892193

Liu SC, Zhang CH, Hong PZ, Ji HW. 2007. Lipasecatalysedacylglycerol synthesis of glycerol and n-3 PUFA from tuna oil: optimisation of process parameters. Food Chem. 103, 1009–1015. http://dx.doi.org/10.1016/j.foodchem.2006.08.037

Márquez-Alvarez CM, Sastre E, Pérez-Pariente J. 2004. Solid catalysts for the synthesis of fatty esters of glycerol, polyglycerols and sorbitol from renewable resources. Top Catal. 27, 105–118. http://dx.doi.org/10.1023/B:TOCA.0000013545.81809.bd

Martin A, Richter M. 2011. Oligomerization of glycerol: a critical review. Eur. J. Lipid Sci. Tech. 113, 100–117. http://dx.doi.org/10.1002/ejlt.201000386

Mollenhauer T, Klemm W, Lauterbach M, Ondruschka B, Haupt J. 2010. Process engineering study of the homogenously catalyzed biodiesel synthesis in a bubble column reactor. Ind. Eng. Chem. Res. 49, 12390–12398. http://dx.doi.org/10.1021/ie101430w

Ortega S, Bódalo A, Bastida J, Máximo MF, Montiel MC, Gómez M. 2014. Optimized enzymatic synthesis of the food additive polyglycerolpolyricinoleate (PGPR) using Novozym 435 in a solvent free system. Biochem. Eng. J. 84, 91–97. http://dx.doi.org/10.1016/j.bej.2014.01.003

Ortega S, Máximo MF, Montiel MC, Murcia MD, Arnold G, Bastida J. 2013. Esteri•cation of polyglycerol with polycondensedricinoleic acid catalysed by immobilized Rhizopusoryzae lipase. Bioproc. Biosyst. Eng. 36, 1291–1302. http://dx.doi.org/10.1007/s00449-012-0874-2 PMid:23263570

Orfanakis A, Hatzakis E, Kanaki K, Pergantis SA, Rizos A, Dais P. 2013. Characterization of polyglycerolpolyricinoleate formulations using NMR spectroscopy, mass spectrometry and dynamic light scattering. J. Am. Oil Chem. Soc. 90, 39–51. http://dx.doi.org/10.1007/s11746-012-2137-4

Panpipat W, Xu XB, Guo Z. 2012. Towards a commercially potential process: Enzymatic recovery of phytosterols from plant oil deodorizer distillates mixture. Process Biochem. 47, 1256–1262. http://dx.doi.org/10.1016/j.procbio.2012.04.024

Pan QY, Yang LP, Meng XH. 2013. Optimization of enzymatic synthesis of tricaprylin in ionic liquids by response surface methodology. J. Am. Oil Chem. Soc. 90, 501–509. http://dx.doi.org/10.1007/s11746-012-2186-8

Richardson G, Bergenstahl B, Langton M, Stading M, Hermansson AM. 2004. The function of a crystalline emulsifiers on expanding foam surfaces. Food Hydrocolloid 18, 655–663. http://dx.doi.org/10.1016/j.foodhyd.2003.11.003

Souza MS, Aguieiras ECG, Silva da MAP, Langone MAP. 2009. Biodiesel synthesis via esterification of feedstock with high content of free fatty acids. Appl. Biochem. Biotech. 154, 253–267. http://dx.doi.org/10.1007/s12010-008-8444-4 PMid:19067243

Saitou K, Homma R, Kudo N, Katsuragi Y, Sato K. 2014. Retardation of crystallization of diacylglycerol oils using polyglycerol fatty acid esters. J. Am. Oil Chem. Soc. 91, 711–719. http://dx.doi.org/10.1007/s11746-014-2416-3

Shima M, Kobayashi Y, Kimura Y, Adachi S, Matsuno R. 2004. Effect of the hydrophilic surfactants on the preparation and encapsulation efficiency in course and fine W/O/W type emulsions. Colloids Surfaces A: Phys. 238, 83–90. http://dx.doi.org/10.1016/j.colsurfa.2004.02.018

Shimada Y, Watanabe Y, Sugihara A, Tominaga Y. 2002. Enzymatic alcoholysis for biodiesel fuel production and application of the reaction to oil processing. J. Mol. Catal. B: Enzym. 17, 133–142. http://dx.doi.org/10.1016/S1381-1177(02)00020-6

Takatori T, Shimono N, Higaki K, Kimura T. 2004. Evaluation of sustained release suppositories prepared with fatty base including solid fats with high melting points. Int. J. Pharm. 278, 275–282. http://dx.doi.org/10.1016/j.ijpharm.2004.03.030 PMid:15196632

Wang Y, Zhao MM, Ou SY, Xie LY, Tang SZ. 2009. Preparation of a diacylglycerol-enriched soybean oil by phosphalipase A1 catalyzed hydrolysis. J. Mol. Catal. B: Enzym. 56, 165–172. http://dx.doi.org/10.1016/j.molcatb.2008.07.008

Xiao YS, Wang Y, Zhang GW. 2012. Optimization of preparation of polyglycerol fatty acid ester catalyzed by Phospholipase A1 in a solvent free system using response surface methodology. Sci. Tech. Food Indus. 33, 191–194.

Yamagata Y, Iga K, Ogawa Y. 2000. Novel sustained-release dosage forms of proteins using polyglycerol esters of fatty acids. J. Control Release, 63, 319–329. http://dx.doi.org/10.1016/S0168-3659(99)00206-0

Zou L, Akoh CC. 2013. Identification of tocopherols, tocotrienols, and their fatty acid esters in residues and distillates of structured lipids purified by short-path distillation. J. Agric. Food Chem. 61, 238–246. http://dx.doi.org/10.1021/jf304441j PMid:23241167

Zhong NJ, Gui ZY, Xu L, Huang JR, Hu K, Gao YQ, Zhang X, Xu ZB, Su JY, Li B. 2013. Solvent-free enzymatic synthesis of 1,3-diacylglycerols by direct esterification of glycerol with saturated fatty acids. Lipids Health Dis. 12, 12–65. http://dx.doi.org/10.1186/1476-511X-12-65 PMid:23656739 PMCid:PMC3680111

Published

2015-09-30

How to Cite

1.
Wan FL, Teng YL, Wang Y, Li AJ, Zhang N. Optimization of oligoglycerol fatty acid esters preparation catalyzed by Lipozyme 435. Grasas aceites [Internet]. 2015Sep.30 [cited 2024Mar.28];66(3):e088. Available from: https://grasasyaceites.revistas.csic.es/index.php/grasasyaceites/article/view/1554

Issue

Section

Research